The sausages were hung on an oven grate and dried for 50 min at 70 °C in an oven for the larger portions (UNOX,
XVC705, Vigodrzere-Podova, Italy) or a drying cabinet for smaller portions (Memmert drying cabinet, U40, Schwabach, Germany). All sausages, in all four setups, were stored at −60 °C after the end of preparation and any other storage/treatments and until analysis. Four experimental setups were performed using cooked pork sausages as a model to meet the LBH589 solubility dmso aims specified for the present study i.e. (1) A setup where the NA levels in cooked sausages prepared with six different levels of nitrite was determined. (2) A five factor 2-level factorial experiment to study the role of erythorbic acid, ascorbyl palmitate, fat content, tripolyphosphate and black pepper on the NA formation. (3) A full central composite experiment to study the effect
of thirteen different combinations of five levels of erythorbic acid and five levels of ascorbyl palmitate on the NA formation. NU7441 solubility dmso (4) To study the role of haem and iron in the NA formation a four factor 2-level factorial experiment was carried out including also erythorbic acid and calcium as factors. Whether there was a significant difference in the NA levels in sausages prepared with the high or the low level of each of the factors in the two 2-level factorial experiments was tested by Student’s t-test at 95% confidence levels. The statistical software Minitab (version 16) was used for setting up the design and for the analysis of the results. The role of different levels of the in going amount of nitrite on the NA formation in sausages, the influence of storage time after preparation and the effect of frying the sausages was studied. First sausages were prepared in accordance with the recipe described above
only varying the amount of in going nitrite. triclocarban Six levels of nitrite was employed i.e. 0, 60, 100, 150, 250 and 350 mg kg−1. Twenty-four sausages, of approximately 25–35 g each, were prepared for each level of nitrite, i.e. a total of 144 sausages. The 24 sausages prepared for each of the six nitrite levels were divided into four sub-groups. Sub-group 1 was packed immediately after preparation (t0) and put into the freezer after approximately 4 h. Sub-group 2 was packed immediately after the drying process (t1) and frozen after about 2 h. Sub-group 3 and 4 were packed immediately after the drying process and stored at 5 °C for 24 h (t2) and then frozen. Sub-group 4 was used for studying the effect of pan frying. These sausages were fried for 10 min one group at a time using the same frying pan. During these 10 min the centrum temperature of the sausage reached 100 °C. The weight loss was registered allowing for calculation of the NA content per kg−1 of the sausages not fried.
Related posts: